View Full Version : Technical help Q & A
- Air injector bracket
- cossie managed zetec turbo???
- cosworth trying to start but wont?
- rs turbo tps help needed
- RS holding back between 2-3k
- Turbo vacum help
- Running problems
- help!frst blue smoke
- bad fuel
- oil filter HELP PLEASE
- cant get brakes working!
- exhaust gaskets
- mfi engine, rev gauge help.
- ST200 idle speed up/down
- focus st2
- Turbonetics E46: Does it need an oilfeed restrictor, and if so: What kind ?
- Ford Focus exhaust manifold/cat
- little escort won't start!!!????
- escort mk6 van lowering springs
- 1.6 zetec to 2.0 zetec whats involved
- rst van project, power to fusebox question (pic)
- gearbox ?
- knackered servo on s1??
- escort rs turbo
- 3rd time lucky
- Cosworth ABS ECU
- how much bhp from this spec?
- 2wd turbo heat shield needed??
- zetec turbo help
- Cosworth 4x4 Head Re-Torque
- ACT sensor causing misfire !! YB, 2wd
- focus tdi wont select 1st or 2nd gear
- orion rear brake lines same as escorts?
- Fiesta TDci air in fuel
- escort cosworth with liners what head gasket?
- oil catch can-to atmosphere or inlet?
- Sierra Propshaft
- Help. Please. Cosworth headache.
- Difference between 1.8 and 2.0 blacktop cams
- I don't have swine flu.
- mondeo zetec 20l poor pick up?
- what plugs small turbo escort
- Mondeo Fuel Cut Off Switch
- A plea for help from the Cosworth Uber Guru's on PassionFord...
- escort mk3 5 speed conversion
- dash light prob. 4x4 saph..
- my engine bay, anything diff?
- is this an ECU?? if so what type
- mondeo zetec central locking
- traction control arm bushes from 4x4 to 2wd???
- whats best supercharger or turbo?
- MFI XR3i to EFI RST conversion
- oil pick up question....
- Mk 5 Cabby Rear Speaker Replacement
- B+M fitting probs
- cossie alternator pulley removal
- How to convert all TOD, MOD, MKV, FLV, AVI, 3GP, etc formats of video/audio for Mac
- Mk 5 XR3i Cabby Clock Removal Problem
- gearbox fouling rollbar escort mk3 help
- Rs turbo series 2 headlights
- Fitting a 2.0 blacktop zetec engine??
- Cossie rep, few problems.
- engine mount problems
- 2LTR ZETEC ONTO bc/ib5 GEARBOX HELP NEEDED
- focus rs 2003
- lowering the rear of my connect
- 99 Escort LX SOHC fuel filter replacement
- rs2000 engine
- how do you fit 4x4 prop bush correctly
- Spec-ing cams?
- problem with kms ecu
- Escort mk5 xr3i rad fan wont kick in ?
- 2wd cossie dizzy drive timing ???
- my rs turbo feels hesitant when it begins boost...?
- help! main beam wont work on my on my mk2 orion
- Brake upgrades - 4 pots, Pedal Box's and Biasing
- exhaust clamps
- RS1800i ABS - How to disable
- oil getting into the water ?
- R&D 6 Speed Dogbox - broken 3rd time
- Cosworth 4x4 power
- Rich smell from 2wd saph cosworth
- 24v conversion into a cossie. help please
- urgent help please!! who has a ybp engine with a 2wd sump
- Sierra 2wd Ignition coil?
- Mk2 Orion/Mk4 Escort Knocking in Reverse!?
- electrics playing up
- Airtec single pass intercooler S2, question?
- my erst cab...not starting..
- Mondeo mk1 rear disc conversion
- oil cooler
- What do cvh worn shells look like?
- crank regrind cvh
- CVH Low Oil Pressure Help Please!!!
- rs turbo firing order ?
- zetec loom
- chip swop
- Mondeo st tdci
- xr3i mk5 wont start (help)
- Driveshaft leak ?
- rs2000 looms mk5/mk6 the same? PATS
- bypassing PATS on mk6 rs2000 engine
- FRST starting issue
- Front wheels out of center
- sierra 2wd cosworth wiper relay
- XR4i drive shafts?
- mfi fucked or not please help
- 3dr Sierra Front wheel bearings
- fitting a 2wd sump on a genuine gasket should i use sealer?
- Ka ECU problem?
- ST 225 power delivery has gone strange
- rs2000 turbo or rs2300 turbo? whats better?
- which adjustable cosworth fuel reg for frst
- mk 6 van exhaust problem
- 2wd propshaft....
- mondeo engine in a tiger cat e1
- What turbo have i got
- need help with st170
- Radio problem after jump starting
- How does an external wastgate work?
- Starting problems
- fuel flap release
- zetec conversion in mk4
- bluefin chip
- Misfire
- Cam Bearings
- 4 to 5 stud conversion adapters
- How to put 5th gear back on?
- ZVH Problem!!
- st170 dual mass flywheel probs
- Turbo Splutter
- RS Turbo problem starting when cold
- Mk4 escort starter motor problem
- Cosworth loom experts. Cosworth managed RST.
- s2 rs turbo starts fine and boost well but as it gets up to temp it struggles to idle
- rs turbo no fuel from metering unit to the injectors ?? please help
- S2 Missing rather badly....
- 3door brakes stopped working!!
- NOISE
- exhaust manifold
- Hot ecu and coil?
- help needed rs turbo s2
- has anyone
- Urgent help needed KE Metering head
- 4X4 dash
- Power steering rack?
- rwd cvh turbo
- Juddering Fiesta
- escort s1 problems
- MK1/MK2??
- St170 hubs
- RWD rear mounted engine advice
- Pulleys for a 4x4 Cosworth
- how many volts should i be getting?
- zetec sierra help
- ignition system with Haltech E8 ecu for YB
- cam belt
- Help! Sheared off locking nut key!
- steering problem
- Car Security companys
- mondeo shocks
- Cosworth 044 fuel pump loom
- Fuel pump relay bridged
- Information needed
- clock shorted wire causing grounding problems
- XR2i 16v clutch pedal problem
- 98 escort 1.4 cvh idoling problem????
- Coil on plug conversion
- help with zetecing my mk2orion SEV
- cat 1 alarm
- comps, 15" 8j grp A
- Question about lower arms
- Possible rebore?
- Ford radio code needed pretty please!
- zetech to turbo
- Erst fuel line size??
- Duratec 2.0 HE - Ignition MAP
- what else could it be?
- Cannot Remove 5th Gear with Puller
- tuning rs2000 to a budget. what/how? carbs?
- Cosworth ABS
- how hot is hot
- mistifying KA overpressure cylinder problem
- Ford Focus Zetec 2001 X Reg Broken Cigarette Lighter Problem Help Please
- rs turbo electrical wiring problem
- tuning people help
- 2wd/4wd sapph inlet diffrence
- xr3i to rs turbo conversion
- air con focus
- Converting Mk6 etate to rear discs
- Centre bush in propshaft
- aeroquip fitting size... need help quick!
- starting problem plz help
- interior change
- 2wd cossie problems...
- Drum to rear disc conversion - mk1 focus 1.8
- saph cossie 4x4 to 2wd, gearbox mount??
- temp sensor
- body pannels
- diff question?
- Educated me!! Sierra shell differences??
- please help!
- Gearboxman big tooth kit - Noicy
- possible pinging/pinking/pre-ignition
- green stuff brake pads for escort rs turbo any good?
- st170 head on a 2002 focus zetec
- What group??
- removing the thermostat - Focus RS
- Mk5 RS2000 sump. Is it the same bolt pattern as....
- rs turbo fuel pump relay
- Escort 6 Problem
- st170 juddering probems
- CFM cams and pulleys
- gear ratio's
- Intermittant ABS issue
- rs turbo engine
- galaxy tdi loosing power
- p1520 intake manifold runner control circuit malfunction
- Focus 2.0 oil pressure
- mk5 zetec s 2ltr conversion help
- 2L fiesta si hesitation
- Alternator Noise Through Speakers
- What sort of power
- 4x4 Cos Revs counter jumping
- Harmonic damper on Cossie engine
- turbo is not well
- brake help-st170
- zetec engine ques
- Painting stainless steel?
- mk4 escort efi and mfi heads and cams....
- Escort Mk6 brake bleeding question
- escort rs wont fire up!?!?!?!
- Motorsport Developments
- Ported and polished 1.8 zetec head
- 2wd saph into 4wd
- finis code
- HELP ABOUT Sapphire cozzy 2WD rear diff ..
- 200 block
- Mk4 xr3i efi - "stable" idle with dismounted IRV!?!?
- my xr2i wont start
- gearbox will it fit ?
- 2001 Ka Ticking, Clicking Noise Which Increases with speed!
- 600bhp clutch
- mk4 fiesta si rear brake problem
- Zetec engine quest - can you fit??
- granada parts question
- pinto swap for cvh
- Ford radio codes
- Rod advise for 2.1 ZVH and CR calculations.
- Rs2000 4x4 as a track car???