Damo V

Firstly, been down Ford to pick up 80 quids worth of bits



My old gearlever gaitor



Had a new one made by a local trimmer, in leather, slightly shorter too, so it doesnt get screwed up as much as it did before



Stripped the engine bay out to clean all the old waxoil off and spruce up the shiny bits



Injectors have been flow tested and cleaned



Had some bits powdercoated, inlet plenum, Map sensor bracket, powersteering resevoir bracket, throttle cabla bracket and thermostat housing



Difference before and after



Lots of polishing



Battery Tray



O/S Bulkhead



Bits to be sorted



Hockey stucks (Genuine Ford)





New old stock lower bumper grill




Old lights


New ones




All been smoked by me... They are actually darker than the pics show, the flash is too bright to show it really








Ready for colour





All stripped out and cleaned up for inspection... VERY VERY clean IMO, much better than I expected really, its hard to see any real grot as such!!









All Waxoiled again....





Rear lamp surrounds cleaned and polished




The rear spoiler had the usual blisters and bubbles in the paint, so was sanded right back, all bad areas were re-fibreglassed then smoothed and filled






Mirrors




Tailgate cleaned up and polished




New spoiler seal



These two pics show how much mud and dirt was compacted into the front section of the N/S bodykit




Kit off... Again in MUCH better condition than expected really...

N/S/F Sill



N/S/R sill



O/S/F sill



O/S/R sill



Quick clean with some petrol to remove old waxoil (you can see now how poorly painted they are at the factory)...

BTW, the brown patches on the floor pan itself is the old waxoil, not rust

O/S/R sill



O/S/R sill from below



O/S/F sill



O/S/F sill from below



N/S/F sill



N/S/R sill



N/S/F sill from below



N/S/R sill from below



After a good scrub up with a wire brush and some coarse paper, then a quick prime and some stone chip, which IMO Ford should've put on in the first place ..

N/S/R sill




N/S/F sill



O/S/F sill



O/S/R sill



The return lips of the front wings are getting a little blow over also, they are beginning to look a little chipped up and tired




All masked up ready for colour



A couple of quick pics in colour and clear, just after painting, I have taken some of the masking off whilst wet to prevent "tearing" once dry I will get some more tommorrow...




Bodykit ready for primer... LOOK at the stone chips!!!






After having all my kit off now, I recommend ANYONE with an ECos, get thiers taken off for inspection, also get the arch liners off or if you can, get yer hand under the arch liner at the bottom of the wings near the kit, there was loads of mud and dirt in there when I checked mine... all cleaned out now though ready for waxoil

..
watch this space....

stew

top car.keep the updates coming mate

AndyRST

you been busy then Damo

Have to say that underneath that bodykit its supprisingly clean and the sills are in excellent condition. Are they the orginal ones or have they been replace at some point?

When the kit was taken off my RST 1 sill was really good condition (like both yours are) but the other side was rusted through badly but have to say im very impressed how clean ALL the underneath of yours looks from the pictures

Work all looks top quality as per usual Damo, look forward to the updates LOL

Lee Reynolds

Twins

iTrader: (18)

Nice work

leesrs240

Looking good keep the pics coming

DanRSturbo

Awesome m8

Damo V

cheers peeps...

Andy... ALL exactly as it left the factory mate, I can DEFO say the bodykit has NEVER been removed since some bloke in Germany put it on ...

Benn 304R

Top stuff there m8, surprised theres no rust there behind the kit.
Bet mine isnt as good when i get the skirts of my coss

Excellent m8, be a shame to see it go

robbie s

Blimey mate you have been busy
Have you finished it yet or are we not going to see you down the pub for another couple of weeks

Drjones

looking good!!!!!!!!!!!!

rapidcossie

was thinking the same! would hate to do that to my saf! would prob be rust galore
pretty amazing the condition of yours...what milage/year is that?

AndyRST

Thats amazing then, either your lucky or its been very well looked after previously

I bet yours will be like mine Benn, no sign of problems until the bodykit comes off and then you wish you hadn't ever removed it

Phil

iTrader: (1)

Good work Damo, it's a nice change to see someone taking preventative action in this section of the forum, rather than cleaning up the mess from lack of

adamS2RST

Damo, top work as usual Keep it up chap, nice one

Damo V

Cheers people... I must admit, I was expecting alot more grot than I found... After 10 years on the road and 107k alot of those as a daily driver... I Was pleasantly surprised really... Though I did waxoyl the car when I bought it over 2 years ago, and I have only done about 10-11k in that time

Everthing I have done is stuff I have been wanting to do since the day I bought it... Just didnt want to have the car off the road on a weekend I might wanna use it .... The way I see it is doing it now, will as Phil says help the car last a good while longer plus the new owner will know EXACTLY what he/she is getting

Andy.. I'd say it is a scenario whereby the car has previously been very well loooked after, its a credit to the previous owner really, when I was looking to buy, I found some in a FAR worse state than this and that could be seen with the bodykit STILL on... There are alot of snotters with alot less miles out there

Rob... Dunno yet .. bit more left to do

Damo V

N/S/F Arch lip



N/S/F sill



N/S/R sill



N/S/R sill from below



O/S/R sill



O/S/R sill from below



O/S/F sill



O/S/F arch lip



Some others from around the car now

Back panel (but of the usual grot around the towing eye but nothing structural luckily)



Quick clean



N/S/R 1/4 panel



O/S/R 1/4 panel



O/S/R chassis rail (above exhaust)



Boot floor and back panel (the slight rust marks are nothing to worry about, simply where the fuel tank rubs)



O/S/R chassis rail (usually above fuel tank)



(from below)


A gallon of waxoyl later .... Boy I pity the person who decides to clean it all off to paint underneath... thats 2 gallons in and on the car now The black stuff dripping out the sills and onto the petrol tank is old engine oil, I sprayed into all the crevises before Waxoyl, IMO it will run into areas waxoyl wouldnt usually be able to











Bodykit now in colour (finished it last night at 11 O'Clock :cry )



Rear bumper ready for primer



Ready for colour

K3V HA

WOW!!! Ya dont want to have mine for a week to do that do ya damo!! Top work mate!!

Seriously, how much would ya charge for somt like that?

Damo V

Its taken me longer than a week mate .... I wont be doing it again I'm afraid

SAFFYCOSSIE

Are you selling that Damo?

Damo V

Yes mate ... afraid so... shortly anyway .. I've already had 2 people tell me I wont actually go through with it though pmsl

M.A.D.RST

Damo, you have done a stunning job there, well done mate
Have you done all the spraying yourself??

Damo V

yup.... all my own handywork mate .. not bad for someone who is self tought and never served an apprentiship or worked in a paintshop ... even if I do say so myself lol


The only thing I wish I did have, is a cleaner environment ... Its the dust which really bugs me

Sticky.

iTrader: (4)

Excellent work mate

Twins

iTrader: (18)

nice work

K3V HA

You sure??!! Top work though matey!!

Just out of interest, how did you get started doing stuff like that?? Just practise on old bumpers n stuff??

A.Moore

Amazing! Someone is going to get a superb car.

Damo V

Cheers peeps, just been down ford and spent another 25 quid on stupid little clips for the kit

Kev, I started when I was 16 mate... jumped straight in and did a full respray... which resulted in this



Just read loadsa books from the library lol... spoke to a couple of people, bought a very good gun (which I am still using and also used for the cossie stuff!!) bought the best materials I could (IIRC the paint laquer hardners and thinners for the estate was over Ł600 and that was 10 years ago...)

ian rst

Liking your work mate, this is the sort of previous owner you would want to have your car after.

Tony Turbo

First time I have looked here mate. I see you work is up to your usual standard. Good job you had an Escort to practice on first last year eh?


Quality stuff

BlackSaff

GOOD EFFORT! Thats mint

Sexy-RS

Well done damo Top work you are ver talented

Dazzi_S2

looks really good mate

M.A.D.RST

Damo, have you put all the kit back on yet? If so i dont suppose you have any pics to show us of it all back together?

Damo V

kit went back on tonight, though the kit and rear bumper are the only clean bits on the car at mo so no decent pics just yet, though yes I do have some ... tommorrow.....

Ryan

Damo V

Here we go...

Benn 304R

looking very nice MR V
Hope you dont mind giving me some advice soon (Tough shit if ya do I will ask anyway ), as im gonna make a start on the underneath of the cossie now the nights are lighter and its getting warmer lol.

Top job m8, dont sell it well not yet anyway, get it through this show season then sell it

Damo V

No probs Benn get it stripped I'll give a diagnosis

Benn 304R

I tell ya know, its not as good as yours lol
Drivers side sill defo needs replacing but hopefully thats the only real bad bit lol

But we shall see, will start a resto thread.