slammedorion

Sounds lovely...

bluntys1rsturbo

cheers mate didnt sound bad considering its not been started in months

just in process of removing turbo

jonny s2

iTrader: (12)

naughty toys these.....

bluntys1rsturbo

they are certainly that, especially with a genuine 230+bhp

received my throttle shaft seals courtesy of rtoc club shop today, must say what a quick turnaround good work

missed my bloody delivery from cgb though so gotta get the mrs go n pick it up this morning before she goes to work as i start before 7am when the sorting office opens.

turbo was sent back to wilky yesterday for a quick check over etc so should have that back next week and back on for that weekend

bluntys1rsturbo

picked my parts up yesterday, so now i can fully rebuild the carb and even have the green shaft seals that never seem to get replaced

also as mentioned changing the dizzy and rotor plus a new set of plugs, will be dropping the oil and sticking new oil/fuel filters on there.

turbo arrived at wilkys place yesterday afternoon so fingers crossed we get a quick turnaround so i can get it back on asap.

will just be a matter of fine tuning the fuelling and setting boost at 23-24psi and then it will get it first trip out this year to donington park for the btcc in april followed by its overly long awaited trip back to wgt for a run on there hub dyno to see if we have gained any power

sridgett

A mate of a mate has got a gt turbo with about 180 bhp
Very fast car

LIFE'S SHORT SO FLOOR IT.

bluntys1rsturbo

whats your mates name as i might know him, i run the r5gtt owners fb page and also media relations/area rep for the renault turbo owners club.

anything 160 and above in a 5 and they are great fun, 200 and above and they are a little animal

sridgett

Sorry mate can't give you a proper answer as he is the friend of a friend and also i live in France

bluntys1rsturbo

no probs fella

i received my new battery for my car earlier in the week, iv said since about 2011 that i wanted to replace it as its never really been too good.

this one is much better and has a far better cca

sridgett

Do R5 gt turbo's have the same engine as the mid engine R5 turbo??

bluntys1rsturbo

no matey the original r5 turbo and turbo 2 engine uses the alpine head and is fuel injected still 1.4 8v though.

the c1j engined r5gtt is carb fed and uses a pretty terrible head in standard form

sridgett

Ok thanks mate. I am not really a renault man more fords but that said there are a few i think yes i can see my self it one of those like r5 turbo,r5 gt turbo,21 2liter turbo and r8 gordini.

bluntys1rsturbo

quick pic i got a bit earlier

not long now until shes back out boosting, cant fecking wait

sridgett

Looking good mate. Love colour.

bluntys1rsturbo

well my turbo has just arrived back with me from my mate, so tomorrows job will be to refit it and then its a matter of rebuilding carb, fit new plugs/dizzy/rotor etc and then get fine tuning all ready for btcc at donington in april then the dyno day the weekend after.

scoooby slayer

iTrader: (4)

I would love to see some v box logs for this sort of 30 - 130 mph stuff so the launch is removed from the equation

bluntys1rsturbo

would be very interesting as it doesnt half shift when on the move, obviously being only a little 1.4 8v its not going to match up to some of the big boys but they certainly punch well above there weight.

going be interesting to see what difference this billet wheel makes and the fuelling leaned out to 11.6-8 at this dyno day in april.

when it did 230bhp i was at 10.6afr @wot which is way rich as you know

scoooby slayer

iTrader: (4)

10s will help a lot mate if shes in the 11s for sure


my 450 hp r32 was in the low 10s on a generic chip at 1 bar and made 280 whp it was so rich it was missing lol

after a map to 11.8 afr at 1 bar it made 388 whp just from the fuelling and ignition tune on a power fc ecu


you should see a healthy increase in power


when and where is this dyno day ? if im available maybe I could pop down run my r33 and bring the vbox with me ?

bluntys1rsturbo

thats some increase just off fuelling and ignition tweaks fella

mine was that rich it was struggling to pull the hub dyno to start the runs

for the boost im running if it makes 240bhp then ill be very happy, as once these engines reach a certain point its hard to get past a certain figure, that little carb is the main restriction.

dyno day is at wgt auto developments middlewich,cheshire. top blokes there and i much prefer to use a hub dyno

bluntys1rsturbo

Turbo is now back on my car and up n running. i noticed it needs a new rubber o ring for idle jet. Gotta rebuild carb anyway so all will be done hopefully within next 2 weeks.

got to tax it next week now and then theres nothing stopping me for taking her out for a good old boosting

bluntys1rsturbo

well i taxed my car online today, and also ordered a few little bits n bobs that are needed.

also took a quick pic looked great with sun beaming on it, not long for some boostage

Glenn_

iTrader: (1)

Its looking well matey.

bluntys1rsturbo

thanks alot glenn appreciate that mate

bluntys1rsturbo

my road tax should arrive today so hopefully when i get home its there, then my good mate justin (ex ep motorsport) at jl automotive has told me to take my car down there so i/we can finish the last few jobs off as it will be much easier than trying do it all on my drive.

whilst sorting though some of my parts im fount genuine renault fuel and oil filters and these will both be fitted when the car is up on the ramps doing oil change etc, i also received my new turbo housing studs as one of mine was damaged in transit so was able only to fit 4/5 of them.

i still have to refit my front and rear strut braces and whilst doing so iv decided to freshen up the front suspension with new top mounts/top hats and top strut bearings as who knows how long they have been on the car and they are going to be taking a bit of stick this year

bluntys1rsturbo

well my road tax didnt show up today fecking dvla

so i decided to give the car a quick bath as it was looking a little dirty from being stood outside the last couple of weeks.

anyway heres a couple of quick pics

COSSIEGAZ

Still looking good mate can't wait to see some vids of it on the move

bluntys1rsturbo

cheers matey should have some cracking vids of it this year.

finally have got to the bottom of the rich running issue and will have it sorted by the weekend, i also discovered a very slight tear in my vacuum hose so was defo leaking there. iv ordered a new length of vacuum hose which ill fit and i have my carb completely in bits awaiting a few bits for it.

COSSIEGAZ

Glad to hear you found the problem should run really nice now, and should sound nice as well.

Looking forward to seeing those vids.

Check out this. Www.thegentlemansjolly.co.uk
My friend runs it and if all goes to plan I'll be helping next year. If you don't mind can you spread the word please, you should see some of the cars taking part.

bluntys1rsturbo

well iv managed to get half day off work on friday so ill be heading to my mates place to sort this carb out, i received the required little bits that will solve the rich running issue earlier today.

i will then hopefully get the carb refitted on saturday and fit the new vacuum hose and fingers crossed just might take the car for a little drive

bluntys1rsturbo

will do mate looks decent

Lambchop

iTrader: (1)

Your car looks awesome mate

I love 5 Turbo's

bluntys1rsturbo

thanks alot fella its getting there now, they are addictive little swines thats for sure

Jay,

iTrader: (4)

Car just gets better mate well done mate ! funny enough a few mates were talking about the best grin car we had ever owned and I have to say my 5gt was at the top of the list ! these cars are great

bluntys1rsturbo

hi mate hope your well, cheers for the kind words really appreciate it

i would honestly have to agree with you i dont think there is another car that punches so far above its weight.

iv managed knock off work early today so waiting for the postie drop my parcels off

COSSIEGAZ

It's amazing how a simple fwd hatchback with a bit of power can give you more of a smile on your face than say a lambo it nissan gtr etc

I've said before I had more enjoyment from the old 206 gti 180 I had than the evo I had, I loved my evo but think it's the fact I was worried where to park it and who was around it where as the pug I just got in and put my foot down everywhere with no worries lol. I'm always impressed how these r5s go and how underrated they are

bluntys1rsturbo

well i had a very productive afternoon iv now fully rebuilt the carb and replaced all the offending items, was a good job id bought another carb as spares as i ended up swapping a few bits over.

i will now be refitting the carb tomorrow and resetting the idle fuelling and idle speed there is now finally light at the end of the tunnel

CrOwSoN15

She's looking well now mate, not long!

bluntys1rsturbo

cheers fella, it will be up and running tomorrow not sure if ill drive it as im popping across to a mates who also owns an r5gtt, he wants me to swap a couple of jets and clean the emulsion tube out on his carb.

here is my carb all back together and ready to go back on, i wish id of taken pics of it when it was in a hundred pieces lol

COSSIEGAZ

You could of cleaned it lol

bluntys1rsturbo

its a carb its meant look dirty

dont worry the important bits eg all the internals are clean enough to eat your dinner off